Common problems · Toyota
Toyota Aygo common problems and recalls
7 sourced problems across the Aygo's generations since 2012, plus 11 DVSA recalls. Enter a registration to see the ones that apply to your exact car.
Free · no signup · recalls, MOT data and researched problems
Aygo Mk2 (AB40) (2014–2022)
Acknowledged by the manufacturer
Recalls, extended warranties, compensation schemes, service actions and statements.
- Recall · ToyotaSteering
Recall: steering column part may fail
A steering column component may not be to specification and could fail, causing a loss of steering. Owners were told not to use the car until it was checked, and affected columns were replaced.
Applies to: Aygo Mk2 built September–October 2014
- Recall · ToyotaInterior
Recall: rear seatbelt stitching may be incorrect
Some rear inner seatbelts may have been stitched incorrectly. Dealers checked them and replaced where needed.
Applies to: Aygo Mk2 built 2020
Reported by owners and the motoring press
Problems at least two independent publishers report, that the maker has not acknowledged. They describe the model, not every car.
Nothing reported that met our bar of two independent publishers.
DVSA recalls for the Aygo Mk2 (AB40)
Listed by DVSA for this model during these build years. Not every car is affected — check yours by VIN on GOV.UK.
- Certain transmission front suspension and battery terminal fixings may not be tightened correctly.R/2023/059 · 24/04/2023
Certain transmission front suspension and battery terminal fixings may not be tightened correctly.
Remedy: Check and tighten all fixings to the correct torque.
Listed for: AYGO X · built 2022
- Possibility of a wrong brake pedal installed.R/2022/286 · 21/11/2022
There is a possibility that the wrong brake pedal was installed.
Remedy: Inspect and if necessary replace Brake Pedal Support Assy.
Listed for: AYGO X · built 2022
- An incorrect tooling setup during the manufacturing of the fuel tank may result in reduced wall thickness or small pin hole in the tank's bottom surfaceR/2018/316 · 21/01/2019
An incorrect tooling setup during the manufacturing of the fuel tank may result in reduced wall thickness
Remedy: Check the serial number and replace the fuel tank if necessary.
Listed for: AYGO · built 2011–2016
- It may not be possible to switch headlights from high beam to low beam or low beam to high beamR/2020/254 · 20/10/2020
It may not be possible to switch headlights from high beam to low beam or low beam to high beam.
Remedy: Replace the Headlamp Units
Listed for: YARIS, AYGO · built 2020
Show 3 more
- Curtain shield airbag straps that support proper airbag deployment might not have been routed correctlyR/2022/288 · 14/11/2022
There is a possibility curtain airbag straps may not have been routed in the correct orientation.
Remedy: Inspect the straps used to assist in curtain shield airbag deployment and correct any improperly assembled straps.
Listed for: AYGO X, BZ4X · built 2021–2022
- Due to an improper lubricant used during the manufacturing process the improper lubricant might contaminate the vacuum check valveR/2022/311 · 14/11/2022
Due to an improper lubricant used during the manufacturing process the improper lubricant might contaminate the vacuum check valve.
Remedy: Replace the VCV (Vacuum Check Valve) on the brake booster.
Listed for: AYGO X · built 2022
- On affected vehicles there is a possibility that the DCM may not complete the shutdown process within a specific period of time when the ignition is turned off causing the DCM to not restart at the next ignition cycle and making the e-Call…R/2023/279 · 12/10/2023
On affected vehicles there is a possibility that the DCM may not complete the shutdown process within a specific period of time when the ignition is turned off causing the DCM to not restart at the next ignition cycle and making the e-Call function unavailable. As a result the vehicles do not comply with relevant regu…
Remedy: The software of the DCM (Data Communication Module) will be updated via an Over the Air (OTA) wireless update.
Listed for: YARIS CROSS, BZ4X, YARIS, HIGHLANDER, RAV4, AYGO, COROLLA, C-HR, RAV4 PHV, HI LUX · built 2020–2023
Measured at MOT: how a 2018 Aygo fails more often
Based on 44,209 first MOT tests of this model at 8 years old (cars first used 2016–2017), compared against every car of the same age and fuel.
Nothing stands out. No category fails clearly more often on this model than on cars of the same age and fuel.
How to read this
These are MOT outcomes for other cars of the same model, age and fuel — not a prediction about this one, and not a fault diagnosis. A high rate means the category is worth checking, not that this car has a problem.
A comparison is only shown where it survives its own margin of error. Where a model is only slightly above average, both rates are shown and no multiple is given, because the data cannot tell the difference.
MOT results reflect how a car has been used and maintained as much as the model itself. High mileage, short journeys and deferred servicing all show up here.
Contains public sector information licensed under the Open Government Licence v3.0. Failure rates derived by FindServiceHistory from the DVSA anonymised MOT test and failure-item extracts.
Aygo Mk1 (AB10) (2005–2014)
Acknowledged by the manufacturer
Recalls, extended warranties, compensation schemes, service actions and statements.
- Recall · ToyotaBody & corrosion
Recall: rear door window glass can come unglued
The glue holding the glass in the rear doors could let go. Dealers inspected and repaired or replaced the rear window glass.
Applies to: Aygo Mk1 (five-door) built 2005–2013
Reported by owners and the motoring press
Problems at least two independent publishers report, that the maker has not acknowledged. They describe the model, not every car.
- Reported by 2 publishersBody & corrosion
Water leaking into the boot and front footwell
The first Aygo is prone to water getting inside: through poorly fitting boot and rear-light seals into the load area, and through a vent into the front footwell. Look for damp carpets, a wet boot floor and heavy condensation. Some owners report repeated repairs, including rear light units replaced several times for water ingress.
Applies to: Aygo Mk1 (2005–2014)
- Reported by 2 publishersCooling
Water pump leaking or failing
Water pump failures are a known weakness of the first Aygo (and its Citroën C1 / Peugeot 107 twins), typically after a few years. Look for coolant leaks and a dropping coolant level.
Applies to: Aygo Mk1 (2005–2014)
- Reported by 2 publishersEmissions, DPF & AdBlue
Exhaust back box rusting through early
The rear exhaust silencer (back box) has a short life on the first Aygo — some have rusted through in little more than two years. Listen for a blowing exhaust.
Applies to: Aygo Mk1 (2005–2014)
- Reported by 2 publishersBody & corrosion
Boot lock failing through wear
The boot lock — and on well-used cars the driver's door lock — can wear out and fail, sometimes after only three or so years. Check the boot opens with the key and the remote.
Applies to: Aygo Mk1 (2005–2014)
DVSA recalls for the Aygo Mk1 (AB10)
Listed by DVSA for this model during these build years. Not every car is affected — check yours by VIN on GOV.UK.
- Steering column may fail unexpectedlyR/2016/149 · 29/06/2016
A component of the steering column may not be to specification and could fail. If this occurs there would be a loss of directional control.
Remedy: The manufacturer will contact keepers of affected vehicles and advise not to use the vehicle. Examine vehicles and on those with the affected component replace the steering column.
Listed for: AYGO · built 2014
- Loss of controlR/2014/172 · 28/01/2015
The front shock absorber rod may have an internal fault which could cause it to break. This could have an adverse affect on the front suspension and the driver's ability to control the vehicle.
Remedy: On affected vehicles replace both front shock absorbers.
Listed for: AYGO · built 2013
- An incorrect tooling setup during the manufacturing of the fuel tank may result in reduced wall thickness or small pin hole in the tank's bottom surfaceR/2018/316 · 21/01/2019
An incorrect tooling setup during the manufacturing of the fuel tank may result in reduced wall thickness
Remedy: Check the serial number and replace the fuel tank if necessary.
Listed for: AYGO · built 2011–2016
- Accelerator pedal may fail to return to idleR/2010/010 · 06/02/2010
It has been identified that on affected vehicles condensation resulting from cold-weather use of the heater or other causes may form on the worn surface of a component within the throttle pedal assembly known as the friction device. If this occurs there is a possibility that in the worst case the accelerator pedal may…
Remedy: Recalled vehicles will have a precision-cut steel reinforcing bar fitted into the accelerator pedal assembly which will create a space in order to reduce the surface tension between the friction devi…
Listed for: AYGO, YARIS, VERSO, AVENSIS, IQ, AURIS · built 2005–2010
Show 1 more
- Directional control may be lostR/2014/020 · 03/03/2014
On subject vehicles there is a possibility that a wld on the rear axle may not be sufficient. In the worst case scenarios this could cause a break in connection between rear axle and the body. This could cause difficulty in controlling the vehicle.
Remedy: Owners of subject vehicles to be contacted by first class post (using DVLA records). Inspect subject vehicles and if fault found replace rear axle.
Listed for: AYGO · built 2013
Measured at MOT: how a 2010 Aygo fails more often
Based on 20,749 first MOT tests of this model at 16 years old (cars first used 2008–2009), compared against every car of the same age and fuel.
Nothing stands out. No category fails clearly more often on this model than on cars of the same age and fuel.
How to read this
These are MOT outcomes for other cars of the same model, age and fuel — not a prediction about this one, and not a fault diagnosis. A high rate means the category is worth checking, not that this car has a problem.
A comparison is only shown where it survives its own margin of error. Where a model is only slightly above average, both rates are shown and no multiple is given, because the data cannot tell the difference.
MOT results reflect how a car has been used and maintained as much as the model itself. High mileage, short journeys and deferred servicing all show up here.
Contains public sector information licensed under the Open Government Licence v3.0. Failure rates derived by FindServiceHistory from the DVSA anonymised MOT test and failure-item extracts.
MOT failure rate: the Aygo against vehicles its age
In our analysis of DVSA's anonymised MOT data for 2024 and 2025, 25.1% of 505,528 initial MOT tests on the Toyota Aygo failed at the first attempt — 8% less often than vehicles of the same ages and fuel types, which failed 27.3%.
AygoCars of the same age and fuel (all makes)
| Age | Tests | Bars | Aygo | Same age & fuel | Difference |
|---|---|---|---|---|---|
| 3–5 years | 107,228 | 12.0% | 13.3% | 8% lower | |
| 6–9 years | 171,763 | 17.0% | 22.3% | 23% lower | |
| 10–14 years | 147,874 | 33.0% | 34.9% | About the same | |
| 15–19 years | 78,663 | 45.7% | 42.9% | 6% higher |
These describe the model, not one car: how vehicles are used and maintained shows up as much as how they were built. Differences are the conservative end of a 95% confidence interval.
Contains public sector information licensed under the Open Government Licence v3.0. Rates and comparisons are FindServiceHistory's own analysis, not DVSA figures.
These describe the model, not one car. Plenty of cars never have the problems their model is known for, and a recall may already have been done on yours. Every problem links to its sources; a reported problem needs two independent publishers before we list it.
Recalls are listed by DVSA for the model around its build date — check a specific car by VIN at GOV.UK. Contains public sector information licensed under the Open Government Licence v3.0.
Common questions
What are the most common Aygo problems?
For cars built from 2012, the problems at least two independent publishers report include: Water leaking into the boot and front footwell; Water pump leaking or failing; Exhaust back box rusting through early; Boot lock failing through wear. Which apply depends on the generation and engine — they are listed generation by generation above, each with its sources.
Has the Aygo been recalled?
Yes. DVSA lists recalls for the Aygo built from 2012, shown above by generation. A recall covers a range of chassis numbers, so not every car is affected — check a specific car by VIN on GOV.UK, or by registration with our checker.
Does my Aygo have these problems?
Not necessarily. These describe the model; many cars never have them, and a well-maintained car is less likely to. Enter your registration above to see the problems for your exact generation and engine, and whether DVSA records an outstanding recall on it. Whether a known problem was fixed is what a service history check shows.
Has this Aygo had the work done?
A known problem matters far less on a car whose dealer records show it was fixed. A service history check returns the manufacturer's own dealership records for a specific car — and there's no charge if we find nothing.
Check a Toyota service historyMore common problems
- Toyota Yaris problems
- Toyota C-HR problems
- DSG and S tronic gearboxes problems
- Ford PowerShift gearbox problems
- Ingenium diesel engine problems
- BMW N47 diesel problems
- Toyota service records and coverage
- Toyota MOT failure rates by model
- Check a specific car's MOT history
- All models — common problems checker